Volume 27, 2020
Minor oils from atypical plant sources / Huiles mineures de sources végétales atypiques
|Nombre de pages||5|
|Publié en ligne||27 avril 2020|
Prunus avium kernel oil characterization: a comparative study of four varieties from Sefrou, Morocco☆
Caractérisation de l’huile d’amande de Prunus avium : étude comparative de quatre variétés cultivées à Sefrou (Maroc)
Laboratory of Spectroscopy, Molecular Modelling, Materials, Nanomaterials, Water and Environment, CERNE2D, Faculty of Sciences, Mohammed V University in Rabat,
Av Ibn Battouta, BP1014,
Accepted: 25 March 2020
Four varieties of Prunus avium (Burlat, Napoleon, Coeur de pigeon, Van) kernel oils were extracted using a soxhlet apparatus with n-hexane as solvent. These oils composition was compared amongst them, with fatty acids, phytosterols and tocopherols identification and physicochemical characterization of said oils. Several differences, such as in oil yield were observed, “Coeur de pigeon” variety being the highest with a 23.5% yield. Twelve fatty acids were identified in all the varieties with linoleic and oleic fatty acids being the most abundant. β-sitosterol, Campesterol and Δ5-Avenasterol were the major compounds in the sterols assay performed. Also, total tocopherols ranged from 352.22 mg/kg (Var. Coeur de pigeon) to 2072.55 mg/kg (Var. Napoleon), with γ-tocopherol being the dominant one. These results suggest that these oils have numerous active compounds that can be further exploited.
Quatre variétés d’huiles d’amandes Prunus avium (Burlat, Napoléon, Coeur de pigeon, Van) ont été extraites à l’aide d’un appareil soxhlet avec du n-hexane comme solvant. La composition de ces huiles a été comparée entre elles : identification des acides gras, des phytostérols et des tocophérols, et caractérisation phytochimique de ces huiles. Plusieurs différences, comme le rendement en huile, ont été observées : la variété « Coeur de pigeon » offrait le rendement le plus élevé (23,5 %). Il est intéressant de noter que cette variété a l’indice de peroxyde le plus faible avec 4,4 meq O2/kg d’huile. Douze acides gras ont été identifiés dans toutes les variétés, les acides gras linoléiques et oléiques étant les plus abondants, suivis par l’acide alpha-éléostéarique, absent dans la variété « Van ». β-sitostérol, Campesterol et Δ5-Avenasterol ont été les principaux composés dans le dosage des stérols effectué. De plus, les tocophérols totaux variaient de 352,22 mg/kg (Variété Coeur de pigeon) à 2072,55 mg/kg (Napoléon), le γ-tocophérol étant le plus important. Ces résultats suggèrent que ces huiles possèdent de nombreux composés actifs qui peuvent être exploités davantage.
Key words: Prunus avium / cherry / soxhlet / tocopherols / fatty acids / phytosterols
Mots clés : Prunus avium / cerise / tocophérols / acides gras / phytostérols
© Y. Aqil et al., Hosted by EDP Sciences, 2020
This is an Open Access article distributed under the terms of the Creative Commons Attribution License (https://creativecommons.org/licenses/by/4.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
During the processing of fruits and vegetables by the food industries, high rates of loss of nearly 90 million tons of food waste are expelled each year. And in addition to the direct consumption of fruits, these food industries produce large quantities of canned fruit, juice, jam, jelly, compotes, marmalade, syrup and several types of soft drinks (Ferretti et al., 2010; Wink, 2016) at the expense of large amounts of waste in the form of stones and kernels. Some of which are already used as edible oil sources in oil mixtures, in paint and varnish formulation, in surface coatings and as cosmetic oils (Helmy, 1990), while others are still presenting a serious problem of elimination.
“Prunus avium” cherries play an important role in markets and processed fruit markets and are used as an ingredient in fruit cocktails, confectionery fodder and maraschino cherries (Gao and Mazza, 1995) and, unfortunately, large amounts of cherry stones are discarded without further use, this not only wastes a potentially valuable resource, but also aggravates elimination problems (Mu et al., 2015).
The cherry tree (Prunus avium L.) belongs to the Rosaceae family, and the Prunoid subfamily occupies the subgenus Cerasus within Prunus genus. The cherries are classified as sweet cherries (Prunus avium), tart (Prunus cerasus) and dwarf (Prunus fruticosa Pall), the first two being ranked among the three most commercially important species in the world (Chockchaisawasdee et al., 2016) and are currently grown in most temperate and Mediterranean countries.
Turkey is the world’s largest producer of sweet cherries, followed by the United States, Iran, Italy and Ukraine. In Morocco, cherry cultivation covers about 1600 ha in area producing some 14 100 tons per year. The production basins are mainly in the region of Sefrou, where 4056 tons was produced from 338 hectares in the 2019 campaign. Cherry cultivation is so important in the Sefrou region that a festival has been dedicated to it every year since the early 20th century.
In addition to Cherries fruit consumption in Morocco, stems and kernels are used for the traditional treatment of certain diseases.
The oil contained in the kernels of the sweet cherry fruit is extracted and sold in France and Germany, for cosmetic uses. Such product does not exist in Morocco, even at the cooperatives level.
Previous research has shown that cherry kernels have abundant nutrients and bioactive constituents, especially fat. Cherry kernel oils have been the subject of numerous studies representing approximately 25–30% of the total dry weight (Bak et al., 2010; Siano et al., 2016) and containing more than 80% of unsaturated fatty acids, mainly oleic acid and linoleic acid. Thus, cherry stones are potentially important resources for vegetable oil and it is important to exploit them nationally.
However no study was conducted on the chemical profile of the different types of these fruits kernels in Morocco. For this reason, this investigation focuses on the development of the non-used kernel that results from this product containing active phytochemical ingredients.
Three sweet cherry (Prinus avium) varieties (Burlat, Napoleon and Coeur de pigeon) and one sour variety (Van) were collected from Sefrou city in Morocco. The fruits were cut open to recover the kernels. The kernels were washed with distilled water and then left to dry at room temperature in shade. The kernels were stored in hermetic bags at 4 °C till further use.
The kernels were brought to room temperature and crushed for the four varieties used in this study. Thirty grams of blended kernels of each variety were crushed to obtain a kernel flour with a granulometry of less than 630 µm. The flour is then placed in a paper thimble and fed into a Soxhlet extractor. The extractor was fitted with a 500 mL round bottomed flask containing 300 mL of solvent under reduced pressure. The oil extraction was carried out with n-hexane on a flask heater at 45 °C for 8 h.
Oils were separated from the solvent using a rotary evaporator (Rotavapor R-100, BUCHI) and kept in sealed brown bottles under refrigeration (4 °C) for further analysis.
The extraction yield was obtained by dividing the amount of the extracted oil to the initial amount of kernels flour used in the extraction and multiplying by 100. A 0.0001 g analytical balance was used for accurate weighing. Where: Wf is the weight of the extracted oil and Wi is the weight of the initial kernel flour.
The peroxide value was determined according to ISO 3960 (2007) standard method, the free fatty acid (FFA) content was determined using the ISO 660 (2009) standard protocol and the acid value was determined mathematically by multiplying the FFA value by a 1.99 factor.
The fatty acid methyl esters FAME composition was determined following EEC/2568/91 protocol (EEC/2568, 2003), by Capillary gas chromatography – CGC, using a Varian CP-3800 (Varian Inc.) chromatograph equipped with an FID. A split injector was used, and the injected volume was 1 μL. The column used was a CP- Wax 52CB column (30 m × 0.25 mm i.d.; Varian Inc., Middelburg, The Netherlands). The conditions for the chromatographic operations were as follows: The carrier gas was helium and the total gas flow rate was 1 mL/min. The initial and final column temperature was 170 and 230 °C, respectively, and the temperature was increased by steps of 4 °C/min. The injector and detector temperature were 230 °C. Data were processed using a Varian Star Workstation v 6.30 (Varian Inc., Walnut Creek, CA, USA). Results were expressed as the relative percentage of each individual FA presents in the sample.
The tocopherol contents of the samples were determined according to the ISO 9936 (2006) standard method using an HPLC equipped with a fluorometric detector (excitation wavelength 290 nm – emission wavelength 330 nm) on a silica column (25 cm × 4 mm). The elution is carried out with a mixture of (isooctane: isopropanol) (99:1) with a flow rate of 1.2 mL/min during the analysis time (20 min). Quantification was carried out by external standard curves of four tocopherols and daily reference of quantitative and qualitative tocopherol standards.
The phytosterols were quantified according to the ISO 6799 (1991) standard method using capillary gas chromatography CGC on an apolar column (Chroma pack) (30 m × 0.32 mm, DI: 0.25 µm, phase: CPSIL8CB). The VARIAN CP-3800 chromatograph is equipped with a divider injector type 1079 (T: 300 °C) and an FID (T: 300 °C). The carrier gas is helium (flow: 1.5 mL/min).
The physicochemical properties of the extracted oil for each variety were measured. The results displayed in Table 1 show that all oils are conformed to the vegetal oil standards for olive and argan oils. The “Coeur de pigeon” and “Van” varieties are the most abundant in oil with yields of 23.5 and 23%, respectively. “The Coeur de pigeon” recorded also the lowest peroxide value amongst all tested samples with a value of 4.4 meq O2/kg oil. Several factors are responsible for high peroxide values, such as exposure to air and sunlight.
Few are the investigations that were conducted previously on Prunus avium. A study conducted on the sour cherries (Prunus cerasus) have reported a similar yield at about 22.5%. Also, the saponification and the iodine values were close to those found by our investigation, with 183 mg KOH/g oil and 122.5 g I/100 g oil. The close values observed are indicative of similarities in the oil composition. However, acid and peroxide values were lower than those obtained here with 1 meq O2/kg oil and 1.6 meq O2/kg oil, respectively (Popa et al., 2011).
Oil yield, Peroxide value and antioxidant activity comparison between the different Prunus avium varieties tested.
Gas chromatography was performed on the obtained oils to determine the fatty acid and phytosterol composition. The results demonstrated that linoleic, oleic and palmitic acids are the most abundant. However, some differences were observed such as the oleic and linoleic percentages in between varieties. The “Van” variety exhibited the highest oleic acid content followed by “Coeur de pigeon”. Also, the “Burlat” variety was the most abundant in linoleic acid with a value of 40.14%. For the “Van” and “Coeur de pigeon” varieties, oleic acid has the highest proportion, while for “Burlat” and “Napoleon” it is the linoleic acid that has the highest value. Similar observations were reported previously; the oleic (C18:1) and linoleic (C18:2) were the predominant fatty acids in sour cherry kernel oils (25.25–45.30 and 35.50–46.06%, respectively) (Górnaś et al., 2016).
This oil contains a high percentage of unsaturated fatty acids. Linoleic and oleic acids represents major unsaturated fatty acids present in most plant based oils. Peanut, cotton and corn oils display higher content of unsaturated fatty acids than saturated ones.
It is estimated that polyunsaturated fatty acids (PUFAs) contribute to 7% of total energy intake and 19–22% of energy intake from fat in the diets of adults. These values are in accordance with the recommended dosage for adults (Kris-Etherton et al., 2000).
The presence of oleic acid in the skin grants it an antioxidant property that has been evaluated previously by DPPH essay.
These findings are different than those obtained by Straccia et al. (2012), where sweet cherry fruits from Campania region in Italy were studied. The investigation reported that the arachidic acid is the major fatty acid (∼ 41%), followed by linoleic acid (∼ 32%) and palmitoleic acid (∼ 8%) (Straccia et al., 2012).
Another interesting observation in the obtained results is the presence of Alpha-eleostearic acid in all varieties. The presence of this fatty acid was previously reported for sour cherry kernel oils such as the “van” variety in our case (Górnaś et al., 2016). Alpha-eleostearic is a particularly interesting fatty acid as it was previously reported to hold antitumor properties (Zhuo et al., 2014).
Fatty acids composition of the different oil varieties.
For sterols, Beta-Sitosterol is by far the most abundant sterol with values ranging between ∼ 77 and ∼ 83%, with “Coeur de pigeon” recording the highest percentage.
Besides Beta-Sitosterol, Sitostanol, Δ5-Avenasterol and Δ7-Stigmasterol are the most abundant compounds, with an advantage for Δ5-Avenasterol for all varieties except “Van”, where Δ7-Stigmasterol is the most abundant.
It was previously reported that sweet cherry oil from Italy contained only about 0.6% of Beta-Sitosterol and about 0.025% of Campesterol (Straccia et al., 2012).
Phytosterols are important ingredients in a wide range of cosmetic products, such as surfactant, emulsifiers, thickeners and other formulations (Folmer, 2003). Vegetale oils extracted from tropical fruits have been previously studied and used to obtain unsaponifiable fractions (Esuoso et al., 2000). The sterol composition of sweet cherry oil (Sitostanol, sigmasterol, Δ5-avenasterol, β-sitosterol…) grants it a rich unsaponifiable fraction that can be used in functional foods and cosmetic uses (Bernardo-Gil et al., 2001) (Tab. 3).
Sterols composition of the different oil varieties.
Liquid phase chromatography was performed on the obtained oils to determine the tocopherols composition.
γ-tocopherol is the major type of tocopherol found in all varieties, with “Napoleon” having the highest content with a value of 1851.8 mg/kg, followed by “Van” (952.3 mg/kg), “Burlat” (482.87 mg/kg) and “Coeur de pigeon” (301.52 mg/kg) (Tab. 4).
Tocopherol content of the different oil varieties.
The study of cherry kernel oil from three sour and one sweet varieties gave out important results. The kernels, though being hard to obtain, have important oil yields reaching 23.5%. The phytochemical values were also adequate, with the peroxide value being 8.2 meq O2/kg oil at most. This oil is linoleic in nature, with alpha-eleostearic acid being the second most important fatty acid. The studied oil also contains a great amount of beta-sistosterol that has numerous important uses. The total tocopherol amounts were important, while varying from one variety to another, with a maximum of 2072.55 mg/kg for the Napoleon variety.
Sweet cherry kernel oil hold within it active ingredient that can be used in several field such as food and cosmetic industries. The composition suggests that the four varieties have a great nutritional value, cosmetically active compounds, while rich in antioxidants in the form of tocopherols. This study could be a scientific testimony for the development of new sweet cherry based products in Morocco.
No funding was awarded to this study.
No conflict of interest.
The authors gratefully acknowledge the help and support of the fellow scientists, colleagues and farmers that were involved in this work.
- Bak I, Lekli I, Juhasz B, et al. 2010. Isolation and analysis of bioactive constituents of sour cherry (Prunus cerasus) seed kernel: an emerging functional food. J Med Food 13(4): 905–910. [CrossRef] [PubMed] [Google Scholar]
- Bernardo-Gil G, Oneto C, Antunes P, Rodrigues MF, Empis JM. 2001. Extraction of lipids from cherry seed oil using supercritical carbon dioxide. Eur Food Res Technol 212(2): 170–174. [Google Scholar]
- Chockchaisawasdee S, Golding JB, Vuong QV, Papoutsis K, Stathopoulos CE. 2016. Sweet cherry: composition, postharvest preservation, processing and trends for its future use. Trends Food Sci Technol 55: 72–83. [Google Scholar]
- EEC/2568. 2003. Commission regulation EEC/2568/91. [Google Scholar]
- Esuoso KO, Lutz H, Bayer E, Kutubuddin M. 2000. Unsaponifiable lipid constituents of some underutilized tropical seed oils. J Agric Food Chem 48(2): 231–234. [CrossRef] [PubMed] [Google Scholar]
- Ferretti G, Bacchetti T, Belleggia A, Neri D. 2010. Cherry antioxidants: from farm to table. Molecules 15: 6993–7005. [CrossRef] [PubMed] [Google Scholar]
- Folmer BM. 2003. Sterol surfactants: From synthesis to applications. Adv Colloid Interface Sci 103(2): 99–119. [CrossRef] [PubMed] [Google Scholar]
- Gao L, Mazza G. 1995. Characterization, quantitation, and distribution of anthocyanins and colorless phenolics in sweet cherries. J Agric Food Chem 43(2): 343–346. [Google Scholar]
- Górnaś P, Rudzinska M, Raczykb M, Misinaa I, Solivenc A, Seglin D. 2016. Composition of bioactive compounds in kernel oils recovered from sour cherry (Prunus cerasus L.) by-products: impact of the cultivar on potential applications. Ind Crops Prod 82: 44–50. [Google Scholar]
- Helmy HE. 1990. Studies on the pigments of some citrus, prune and cucurbit seed oils when processed with or without cottonseed oil. J Am Oil Chem Soc 67(6): 376–380. [Google Scholar]
- ISO 660. 2009. Corps gras d’origines animale et végétale – Détermination de l’indice d’acide et de l’acidité. [Google Scholar]
- ISO 3657. 2002. Corps gras d’origines animale et végétale – Détermination de l’indice de saponification. [Google Scholar]
- ISO 3960. 2007. Corps gras d’origines animale et végétale – Détermination de l’indice de peroxyde. [Google Scholar]
- ISO 3961. 2009. Corps gras d’origines animale et végétale – Détermination de l’indice d’iode. [Google Scholar]
- ISO 6799. 1991. Détermination de la composition de la fraction de stérol – Méthode par chromatographie en phase gazeuse. [Google Scholar]
- ISO 9936. 2006. Corps gras d’origines animale et végétale « Détermination des teneurs en tocophérols et en tocotriénols par chromatographie en phase liquide à haute performance ». [Google Scholar]
- Kris-Etherton PM, Taylor DS, Yu-Poth S, et al. 2000. Polyunsaturated fatty acids in the food chain in the United States. Am J Clin Nutr 71(1): 179S–188S. [CrossRef] [PubMed] [Google Scholar]
- Mu XP, Aryal N, Du JM, Du JJ. 2015. Oil content and fatty acid composition of the kernels of 31 genotypes of Chinese dwarf cherry [Cerasus humilis (Bge.) Sok.]. J Hortic Sci Biotechnol 90(5): 525–529. [CrossRef] [Google Scholar]
- Popa V, Misca C, Bordean D, Raba DN, Stef D, Dumbrava D. 2011. Characterization of sour cherries (Prunus cerasus) kernel oil cultivars from Banat. J Agroaliment Process Technol 17(4): 398–401. [Google Scholar]
- Siano F, Straccia MC, Paolucci M, Fasulo G, Boscaino F, Volpe MG. 2016. Physico-chemical properties and fatty acid composition of pomegranate, cherry and pumpkin seed oils. J Sci Food Agric 96(5): 1730–1735. [CrossRef] [PubMed] [Google Scholar]
- Straccia MC, Siano F, Coppola R, La Cara F, Volpe MG. 2012. Extraction and characterization of vegetable oils from cherry seed by different extraction processes, pp. 391–396. [Google Scholar]
- Wink M. 2016. Alkaloids: Toxicology and health effects. In : Encyclopedia Food Health. [Google Scholar]
- Zhuo RJ, Wang F, Zhang XH, et al. 2014. α-eleostearic acid inhibits growth and induces apoptosis in breast cancer cells via HER2/HER3 signaling. Mol Med Rep 9(3): 993–998. Spandidos Publications. [CrossRef] [PubMed] [Google Scholar]
Cite this article as: Aqil Y, Ouassor I, Belmaghraoui W, El Hajjaji S. 2020. Prunus avium kernel oil characterization: a comparative study of four varieties from Sefrou, Morocco. OCL 27: 24.
Les statistiques affichées correspondent au cumul d'une part des vues des résumés de l'article et d'autre part des vues et téléchargements de l'article plein-texte (PDF, Full-HTML, ePub... selon les formats disponibles) sur la platefome Vision4Press.
Les statistiques sont disponibles avec un délai de 48 à 96 heures et sont mises à jour quotidiennement en semaine.
Le chargement des statistiques peut être long.